Ignition System. 1. Describe the primary circuit in an ignition system: -Battery -Ignition switch...

Ignition System

• 1. Describe the primary circuit in an ignition system:

• -Battery

• -Ignition switch

• -Ballast resistor

• -Primary windings in coil

• -Points or transistor switch

Ignition System

• 2. Describe the Secondary circuits of an ignition system:

Spark plugs, plug wires, cap rotor and Secondary windings in the coil.

Ignition System

• 3. Explain how the ignition system works?

• Low voltage is in the battery, it goes through the primary coil, the circuit collapses, the voltage surges into the secondary windings then goes through the rotor through the distributor cap, through the plug wires, and the spark plugs. (This takes place when the piston is at TDC on the compression stroke.)

Ignition System

• 4. What is timing?

• It is when the spark plug sparks just at the right time. Usually 6 degrees before TDC when idoling. The spark timing advances (changes) when the RPMs increase.

Servicing The Ignition system

1. Use this battery tester, (hydrometer)when checking the condition of the battery.

Servicing The Ignition System

2. Use a wire feeler gauge to gap a spark

plug, not a “spark plug gaper”.

3. Tune up specifications are the settings and readings for the engine.

4. Bend the ground electrode on the spark plug to adjust the gap.

5. Battery service-

Always check the hold down bracket and battery connections.

6. Battery service

- Connect the negative cable to the ground away from the battery when jumpstarting to avoid sparks, when jump starting a car, to avoid an explosion.

7. Cold cranking amps are an indication of a batteries power.

8. Baking soda is great for neutralizing acid on battery posts.

9. These are the tools needed to service the battery. You will use these tools to do the lab work for “service battery”

The End

Ignition System. 1. Describe the primary circuit in an ignition system: -Battery -Ignition switch...

Documents

Ignition Systems Or….. How to be a bright spark. IGNITION SYSTEM Magneto Operation Coil Soft Iron Core Secondary Windings Primary Windings Engine Driven

Power Losses Calculations in Windings of Gapped …oa.upm.es/37148/1/INVE_MEM_2014_197924.pdf · Power Losses Calculations in Windings of Gapped ... losses calculation in windings

Imrie® Diagnostic Testing · Ignition Coil ‐ Spark test .....3 Transistor Controlled Ignition (TCI) ‐ Primary voltage test.. 4‐5 ... module air gap, the edge gap, the kill

VeloCruz • PO Box 902021 • Sandy, UT 84090 · Ignition Circuit The ignition circuit consists of an ignition coil with the primary winding, ... Normal Running When the throttle

"Magnetics Design 3 - Windings"

Ignition - healey6.com Manual/Ignition.pdf · IGNITION Section Bel The ignition system consists of two circuits—primary and secondary. The primary circuit includes the battery,

Single-phase transformer - Montefiore Institutemontefiore.ulg.ac.be/~geuzaine/ELEC0431/2_Transformer.pdf · Single-phase transformer 2 windings (primary & secondary) around a magnetic

Presentation for Motor Windings

Neutral Safety Switch to Relay (Truck) or Relay to Ignition Switch (Truck) (Auto. Trans.) Starter Solenoid Feed Primary Ignition Resistance Bypass Instrument and Panel Lights, (Fused

Synchronous Machine Armature Windings

Ppt. on Transformer Windings (1)

Ignition coil primary bobbin issue analysis

THREE PHASE PADMOUNTED TRANSFORMER … · Oil Tank, Windings, ... 5’ From Transformer to Building Wall ... Poured Foundation (slab) – Primary and Secondary Cables Have no

ACDSee PDF Image. - ARTC coil A primary/secondary circuit malfunction Ignition coil B primary/secondary circuit malfunction Ignition coil C primary/secondary circuit malfunction Ignition

RA890G Protectorelay™ Primary Control - Honeywell...RA890G PROTECTORELAY PRIMARY CONTROL 60-2035—10 4 a. For the ignition, use Honeywell Specification no. R1061012 Ignition Cable

IGNITION SYSTEM SERVICE Ignition primary service. Ignition secondary service. Ignition timing and advance. Ignition oscilloscope testing

Armature Windings

CDI Ignition Electronic Ignition Overview (The BIG Picture)rg500delta.com/RG500_magneto_and_ignition_files/Electronic Ignition... · CDI Ignition Electronic Ignition Overview

Chapter 9 Ignition Systems page 147. Basic Ignition System Operation charge builds up in coil (12 volts in) creates a magnetic field (windings of wire)

HYDEC 1070 aluminium windings for electro-technical ... · HYDEC 1070 aluminium windings for electro-technical applications ... windings for electro-technical applications such as