View
217
Download
0
Category
Preview:
Citation preview
8/2/2019 Clarification of Kulaora Sherpur
1/36
POWER GRID COMPANY OF BANGLADESH LIMITED
Design, Supply, Erection, Testing & Commissioning of Two New 132/33kV Air Insulated Switchgear
(AIS) Substation at Kulaora and Sherpur on Turnkey Basis[Contract No. PGCB/SS/132/Kul-Sher/01]
CLARIFICATION NO. 1
Pre-bid meeting was held on 16 January, 2012 as per clause 7.4 of Instruction to Bidders of Volume 1 of 3 of the Biddingdocument. Clarifications to the queries received from the prospective bidders on, before and after the Pre-bid meetingare given below, which will form part of the Bidding documents. Attendance Sheet of the meeting is enclosed.
SN. Reference and Queries of Prospective Bidders Reply (PGCB)
1 Volume 3 of 3, Bid Data Sheet, Schedule AThe scope includes 3 Nos. of 2000A, 33kV isolatorsare mentioned. However, as per SLD DrawingNos.PGBD/DESIGN/2011/K-S/E-01 &PGBD/DESIGN/2011/K-S/E-02, 4 Nos. of 1600A &1 No. of 2500A, 33 kV Isolators are required. Kindly
confirm the requirement.
3 sets of 33kV, 2000A Isolators without earthswitch are required for each new Substation.The Single Line Diagrams (SLD) of the biddocument are revised.
Please refer to item no. 14 of Addendumno.-1.
2 Kindly furnish following data for Kulaora andSherpur SS-
o Conductor type & configuration to be usedfor 132kV & 33kV equipmentinterconnection.
o Conductor type & configuration for 132kV
& 33kV main bus.o Conductor type & configuration for 132kV
& 33kV bays jack bus, jumpers & droppers.
Conductor for main Busbar132kV & 33kVshall be Twin FINCH(1113mcm) ACSR.
Conductor for jack bus, equipmentconnection and droppers for 132kV & 33kVshall be single FINCH(1113mcm) ACSR.
3 Kindly confirm whether the isolators shall beElectrically ganged operated (Individual operatingbox for all phases) or Mechanically ganged operated(One operating box for 3 pole operation) for the
Kulaora and Shepur SS.
All isolators shall be Mechanically gangedoperated.
4 Kindly confirm whether 132kV & 33kV isolator earthswitches shall be manual operated or Motor operatedfor Kulaora and Shepur.
132kV & 33kV isolator earth switches shallbe manual operated.
5 132kV & 33kV control & relay panels will be installed Confirmed
8/2/2019 Clarification of Kulaora Sherpur
2/36
7 Control room building Floor plan is provided onlyfor first floor. Kindly furnish floor plan for ground
floor also.
Provision for one store room for spares/toolsand one staff waiting room with toilet facility
are to be considered in the Ground floor ofthe main control building.
8 Details for earthing conductors to be used for mainearth grid, risers, equipment & structure earthing,panel earthing etc. is not mentioned in Biddingdocuments. Kindly Furnish.
Please refer to section-7 of volume 2 of 3 ofthe bid document.Earthling system shall be designed accordingto the specification of the bid document andthe result of soil resistivity test conducted atthe time of detail engineering after contractaward.
The preliminary bid design shall be based ona value of 100 ohm meter soil resistivity asstipulated in the bid document.
9 For Extension of Existing 132 kV AIS SS at Jamalpur:Volume 3 of 3, Schedule A
As per the scope of work and SLD; 2 Nos. of 2000AIsolators without ES are required for bus coupler
bay. However, these isolators are not included inprice schedule. Kindly confirm.
The price schedule is revised.Please refer to item no.17(i) of the
Addendum no.-1.
10 Volume 3 of 3, Schedule AAs per the scope of work and SLD, 6 Nos. of 2 core132kV CTs are required for bus coupler bay and 6Nos. 4 core 132kV CTs are required for line bays.However, in price schedule additional 15 Nos. 4 core
CTs are indicated. If CTs for existing bays are to bereplaced with these 15 nos CTs then dismantling forexisting CTs and scope for structures & foundationsfor these additional CTs need to be confirmed whichis not mentioned either in scope or price schedule.Kindly confirm.
For 15 nos. of existing CTS;Dismantling of the existing CTs & structures,supply of new CT with new structures andmodification of the existing CT foundations
are to be considered under this tender scope.
Please refer to item no.17(ii) of theAddendum no.-1.
11 Kindly furnish following data for Jamalpur SS -
* Conductor type & configuration to be used for132kV equipment interconnection.* Conductor type & configuration for 132kV mainbus.* Conductor type & configuration for 132kV bays jack
Conductor for existing main Busbar132kV issingle MALLARD (795mcm)ACSR.
Conductor for existing jack bus, equipmentconnection and droppers are singleGROSSBEAK (636mcm) ACSR.
8/2/2019 Clarification of Kulaora Sherpur
3/36
13 Kindly confirm whether 132kV & 33kV isolator earthswitches shall be manual operated or Motor operatedfor Jamalpur Substation.
132kV isolators shall be motor operated andearth switches shall be manual operated forJamalpur SS.No 33kV isolators is required for JamalpurSS.
14 We presume that all 132kV control & relay panels willbe installed in existing control room and enoughspace is available in control room for JamalpurSubstation.
132kV control & relay panels shall beinstalled in the existing control room. Someminor modification like dismantling/remakingof partition wall, floor & wall re-finishing etc.
15 Details for earthing conductors to be used for main
earth grid, risers, equipment & structure earthing,panel earthing etc. is not mentioned in Biddingdocuments. Kindly Furnish.
Please refer to section-7 of volume 2 of 3 of
the bid document.Earthling system shall be designed accordingto the specification of the bid document andthe result of soil resistivity test conducted atthe time of detail engineering after contractaward.The preliminary bid design shall be based ona value of 100 ohm meter soil resistivity asstipulated in the bid document.
16 Kindly furnish soil investigation report for existingsubstation with details such as safe bearing capacityfor soil, soil strata etc. to assess the civil quantities.Also kindly confirm whether pile foundations areenvisaged for Jamalpur substations.
Soil investigation report for existingsubstation with details are not available.Bidders may carryout investigation at theirown responsibility.
17 As per price schedule, civil items for modification of
existing control room has been mentioned. Kindlyfurnish detailed information about the modificationwork for Jamalpur Substation.
Some minor modification likedismantling/remaking of partition wall, floor &wall re-finishing etc.
18 Vol. 2/3 Drg No. PGCB/DESIGN/2011/K-S/E-06
Please provide us the section and layout drawing ofexisting Jamalpur 132kV instead of foundationdrawing.
The sections and equipment layout drawingsare not available now. Bidders may visit thesite.
19 Vol. 2/3 Drg No. PGCB/DESIGN/2011/K-S/E-10,Drg No. PGCB/DESIGN/2011/K-S/E-11, Drg No.PGCB/DESIGN/2011/K-S/E-12There are 110V and 48V DC distribution scheme andLV AC di ib i h f b h K l d
The existing LVAC and DC distribution board
8/2/2019 Clarification of Kulaora Sherpur
4/36
8/2/2019 Clarification of Kulaora Sherpur
5/36
24 Vol. 3/3 Schedule A, SA-22, SA-23, SA-24In the schedule A, SA-23 is omitted. Please provide it.For current transformer and voltage transformer thetechnical details of SA-22 and SA-24 including ratio,number of cores, accuracy class and burden etc. doesnot correspond with drawings and technicalspecification.Please clarify the technical requirement for currenttransformer and voltage transformer in this scope.
The missing page SA-23( rev.1) is attachedherewith.The drawings are revised and attachedherewith.Please refer to Addendum No.1.
25 Vol.1/3, Section-8, Clause No. 14.2
i)Please confirm that VAT applicable for local work
such as transport, civil work, erection work will bepaid by PGCB.
ii)Same clause applicable for Income Tax & otherTaxes for local work will be paid by PGCB.
iii)No bill will be deducted from the source bill. If anyTaxes applicable will be paid by PGCB.
i) Confirmed.
ii) PGCB will pay source Taxwhich is deductible as perIncome Tax law.
iii)Confirmed.
26 Existing System for Telecontrol & Telemetering isAREVA make. Please confirm that other make isacceptable also.
Please refer to item no. 1L, 2L & 3Lof Schedule-A of Volume 1 of 3and item no. 21 of Addendum -1.Telecontrol & Telemeteringequipment to be supplied underthis tender scope is to becompatible with existing systemusing protocol IEC 60870-5-101/104.
27 The Bus bar shown 2000A for 132 kV & 33 kV Systemis 2000A. Please confirm whether it will be twinconductor or single conductor.
Please refer to above reply of sl.No. 2 & 11
28. What will be current rating of Jack bus & jumpering.If need the twin conductor please confirm.
Please refer to above reply of sl.No. 2 & 11
29 Please confirm that the land is fully developed &surrounded by boundary wall.
The land for Sherpur and Kulaorashall be developed and boundarywall shall be constructed by PGCB.Land development is underprocess.
8/2/2019 Clarification of Kulaora Sherpur
6/36
32. Volume 1 of 3 , Section I, ITB 21.1Is the Bid Security Bank Guarantee acceptable fromany International Bankers like CITI, HSBC,
STANDARD CHARTARD etc. who are havingbranch in Bangladesh?
The bid security may be issuedfrom any branch of foreign bank
located in Bangladesh.
34 Volume 1 of 3 , Section I ITB 22.2Since there is no standard format for Power ofAttorney available in the Bid Document, we presumethat it can be made in our standard format.
Confirmed.
35. Volume 1 of 3 , Section I ITB 19.1Whether Expenditures at Employers Country to bequoted with Local Currencies and under such statuswhat are all prevailing Taxes & Duties applicable tobe considered by Bidder
Please refer to the clause no. 14.2 ofS.C.C.(section-9, volume 1 of 3)
36 Volume 1 of 3 , Section I ITB 18.6As per BDS The prices quoted by the Bidder shall be
fixed ( Price adjustment will be zero ) OR adjustableto reflect changes in cost .. & both type areacceptable to PGCB.
Being ICB tender, how the tenders will be evaluatedin case of Bidders quoting differently.
Please refer to item no. 2 & 7 of
Addendum-1.
37 Appendix 1 : Terms & Procedures for PaymentWhat will be the process of payment for the retained5%+5% in the event of non-readiness of IncomingLine & Substation
As per bid specification.
38 Volume I Appendix 1 : Terms & Procedures forPayment
i) Who will bear the expenses of Letter of Credit ?
ii)What will be the negotiable documents for Letter ofCredit ?
iii)For Installation & Service 45days is stipulated fromReceipt of Invoice. Our proposal is to advance it to atleast 30 days
i) All costs in connection with
Letter of Credit within Bangladeshshall be borne by the Employer andoutside Bangladesh shall be borneby the Financial institution or theContractor as appropriate.ii) As per terms & conditions of LC.iii) bid ifi i
8/2/2019 Clarification of Kulaora Sherpur
7/36
40 Price BasisWe understand that for Equipment to be Suppliedfrom abroad is CIF we presume that it should be
CIF Bangladesh Sea Port or Airport port as may beapplicable.
Confirmed.
41 Volume 3 of 3 bid SecurityAt the end, it is prescribed as This guarantee issubject to the Uniform Rules for Demand Guarantees,ICC Publication No. 458 However , as per latest ICCPublication no will be 758 as updated version . Pleasehave acceptance of the latest version.
Please refer to item no.15 ofAddendum no.1
42. Volume 1 of 3 Clause no 4.3 towards Bidder & theirOfferIn case we participate in this tender as a Bidder , canwe offer our equipments to other Bidders as a sub-supplier / sub-contractor .
Yes, Bidder can offer their ownmanufactured equipment to otherbidder as a sub-supplier/sub-contractor.
43 Volume 1 of 3 , Clause no 2.6 Manufacturer(s)/Subcontractors
Please confirm whether Authorization is must forproposing Equipments from your make List WHILEto proposed other makes , we are to submit necessarycredentials to substantiate the same in addition toprescribed makes.
Manufacturers authorization isrequired in all cases; i.e. if
equipment proposed from the listmentioned in section-3 of vol. 1of 3or proposed from other.Manufacturers authorization is notrequired in case of manufacturer isthe bidder.
44. Please provide the soil resistivity. Please refer to above reply of sl.No. 15
45. Please confirm the switchyard fenced area. Since asper the Layout Plan furnished with the tenderdocuments, the total area is given only.
Switchyard security fence shall beconstructed by PGCB.
46. We presume that the transmission line sideconductor, insulator and hardware are excluded from
our scope of work.
Confirmed.Please refer to Clause no.
2(Terminal Points) of Section-1 ofvolume 2/3 of bid document.
47. We presumed that LT power shall be provided bycustomer on 415V switchyard ACDB located inswitchyard control room. Further distribution of LTpower to various equipments in switchyard is
Please refer to the bid drawings for(draw. no. E-12) for LVACDistribution scheme for Kulaoraand Sherpur.
8/2/2019 Clarification of Kulaora Sherpur
8/36
49. Please confirm the orientation of the 132 kV line bays. The orientation of and location ofthe terminal points is mentioned inthe layout drawings which will be
finalized at the time of detailengineering after contract award.
50. Please provide the details of the earthing system to beconsidered for the switchyard (Including the materialto be used for main earthmat, risers, rod/pipeelectrodes etc.). Please also specify the fault level forwhich the main earthmat should be designed.
Please refer to above reply sl. no.15.
51. Please confirm the type of conductor to be used forMain Bus, equipment interconnection and Jack Bus(including droppers) for 132 kV switchyard.
Please refer to above reply sl. no.2& 11.
52. We presume that the direct stroke lightningprotection of the switchyard is to be achieved throughshield wire.
Yes, your assumption is correct.
53. Please specify the electromechanical strength of thedisc insulator and cantilever strength for the postinsulators for the 132 kV switchyard.
Please refer to Appendix-A10.1 &A10.2 of Schedule-A, Page SA-44 ofVolume 1 of 3.
54. The quantity of 33 kV disconnector as shown in theSLD (DWG NO: PGCB/DESIGN/2011/K-S/E-01)and SLD (DWG NO: PGCB/DESIGN/2011/K-S/E-
02) is not matching with the Schedule B3, Vol 3 of 3furnished with the tender documents.
Please refer to the above reply sl.no. 1
55. Volume 3 for Fibre Optic Multiplexer Equipment forCommunication and Protection
Considering specification for the same havingAREVA make existing , can we have necessary Panelfrom India with AREVA(UK/France ) make Relay
Please refer to item no.10 ofAddendum-1.
56. Please provide the existing earthmat layout alongwith details of the switchyard earthing system.
For Jamalpur SS, existing earthmatdrawing is not available.
57. Please provide the soil resistivity.Please provide the type of conductor to be used forMain Bus, equipment interconnection and Jack Bus
Please refer to the above reply sl.no. 2, 11 & 15.
8/2/2019 Clarification of Kulaora Sherpur
9/36
59. Please confirm whether the existing DC system is ableto cater for the loads of the 2 nos. 132 kV Line Bay and1 no. 132 kV Bus Coupler Bay for Jamalpur.
Confirmed.
60. Please confirm whether the existing switchyardcontrol room has sufficient space to accommodate thecontrol and relay panels for the new bays as well asfor the AC and DC system for Jamalpur.
Yes.Also please refer to above replysl.no. 17
61. As per the technical specification section 3, page-17,of volume-II it is specified that the DisconnectorsEarth switch shall be motor operated (Locally) but in
the technical requirement of Disconnectors it ismentioned that it should be manual operated. Kindlyconfirm whether this project requires manual/motoroperated Earth Switch.
Please refer to above reply sl.no. 4& 13.
62. Please confirm whether this project needs electricallygang operated Disconnectors.
Please refer to above reply sl.no. 3& 12.
63. Vol 1, Section 7, 30.1 (a), page 7-37The Contractor Shall not be liable. To pay liquidateddamages to the employer.We kindly request you to delete exclusion of paymentof LDs from the consequential damages clause.
As per bid specification.
64. Vol 1, Section 7, 30.1(b), Page 7-38The aggregate liability of thecontractor..with respect topatent infringmentWe kindly request you to remove the exclusion of theobligation of the Contractor to repair or replace
defective Equipment from the overall liability cap.
As per bid specification.
65 Vol 1, Section 7, 37.3, Page7-44The party who has . WithGCC Cl 40We request you to amend "The time extensionprovided to the contractor should be equal to the
As per bid specification.
8/2/2019 Clarification of Kulaora Sherpur
10/36
Vol 1, Section 7, 40, Page7-49The time for completion of any ofthe followingContractor should be entitled to extension, if theContractor is unable to carry out of its obligationunder the Contract for any reason attributable to theEmployer, including but not limited to the Employersfailure to provide possession of or access to the Siteor other areas or failure or delay to obtain anygovernmental permit necessary for execution and/ orcompletion of the facilities.
67. Vol 1, Section 8, 26.2, Page 8-14 & 15If the contractor fails to .. Under thecontractWe request you to please limit the value of Liquidateddamages. We also request you to consider Liquidateddamages as 0.5% per week of the contract valuesubject to maximum of 5% of the contract value asthis is applicable in all international tenders like WorldBank, JBIC and ADB funded project, So we requestyou to consider the same.
As per bid specification.
68. Vol 1, Section 8, ABG 6E-9The maximum. to us.We request you to add the following after to us"HOWEVER ANY SUCH REQUEST FORREDUCTION IN THE GUARANEE VALUE SHOULDBE SUPPORTED BY THE BENEFICIARY CONSENT
LETTER.
As per bid specification.
69. Vol 1, Section 8, ABG 6E-9The guarantor agrees to . One time extensionWe request to amend the line as " The guaranteeshall be valid for 12 months and the same shall beextended for every 12 months based the request fromemployer"
As per bid specification.
70. Vol 1, Section 8 , 1.1 & 8.2 Page 8-2 & 8-3DeliveryPeriod-18MonthsCompletion period 20 MonthsPlease let us know the delivery period as 18 Monthsand 20 Months are mentioned. Please let us know thedelivery period
Please refer to item no. 6 ofAddendum-1.Please also refer to clause 1.2.2 ofSection-3, Volume 1 of 3.
8/2/2019 Clarification of Kulaora Sherpur
11/36
72. Vol 3, Section 3, 1A-4 & 2 A -4Disconnector with Motor Operated isolator andManual Operated earth SwitchPlease let us know whether Mechanically OperatedE/S is required or electrically Operated E/S is requiredas earlier projects are offered with electrically Offeredearth switch
Please refer to above reply sl.no. 4& 13.
73. Vol 2, clause3.4.5.6 page3/10-11Mandatory Maintenance Equipments :SF6, GasFiltering, Drying and Storage TankWe propose to offer Portable SF6 gas filling and
evacuating device which shall meet the requirementof filling the gas. Please let us know the same
This item is not required as perSection-4(Mandatory Spares),Shedule-B2 (Price Schedule)
Volume 3 of 3.Also refer to item no. 26 to 28 ofAddendum -1.
74. Volume 1, page 3-8, Section 3-Evaluation &Qualification Criteria, 1st Paragraphfor protection relay including substation automationsystem and fiber optic multiplexer equipment onlyauthorization letter from those shall be supplied from
PGCBs selected manufacture as stated in section 5and section 14, volume 2 of 3 of the biddingdocument. the following clarification and information isrequire :
i) what does this paragraph imply ?ii) Section 5 and section 14, volume 2 of the
bidding document does not have selectedmanufacturer listed. Who are they ?
Please refer to the clause 5.12.1page no. 5/24 of section-5(volume2 of 3) and item no. 10 ofAddendum-1 for protection relayand control system includingcomplete panels.
Please refer to above reply sl. no.26 for fiber optic multiplexureequipment.
75. Section 10 National Load Dispatch Centre (NLDC)Control Facilities 10.1 Scope : In order to provide thetele control facilities required at the National LoadDespatch Centre (NLDC) the following provisionsshall be made under this Contract. Necessarymodification in the software and hardware at NLDCmaster station is also to be done under this contractto accommodate all the new system extended underthis contract. The question is:
i) Who is the existing software and hardware supplierat NLDC master station at Rampura, Dhaka?
i)AREVA, France.
76. There are communication equipment in FenchuganjSS and Jamalpur SS that the contractor has tointerface with. The question are:
i) Are these equipments new or existing ?i)These equipment are existing.ii)Please refer to above reply sl. no.
8/2/2019 Clarification of Kulaora Sherpur
12/36
Design, Supply, Erection, Testing & Commissioning of Two New 132/33kV Air InsulatedSwitchgear (AIS) Substation at Kulaora and Sherpur on Turnkey Basis
[Contract No. PGCB/SS/132/Kul-Sher/01]
Addendum No. 1
Volume 1 of 3
1. Section no. 1: Instructions to Bidders, Page no. 1-3, Sub-clause 2.1:
The text Design, Supply, Erection, Testing And Commissioning of 230/132kV Air Insulated Switchgear (AIS)Substation at Barisal on Turnkey Basis is replaced by Design, Supply, Erection, Testing and Commissioning
of Two New 132/33 kV Air Insulated Switchgear (AIS) Substations at Kulaora & Sherpur and extension ofexisting 132kV Substation at Jamalpur on Turnkey Basis.
2. Section no. 2: Bid Data Sheet, Page no. 2-4, Sub-clause ITB 18.6:
The text of sub-clause ITB 18.6 is replaced by following:ITB 18.6 The prices quoted by the Bidder shall be adjusted in accordance with clause no.11.2
of General Condition of Contracts(GCC) of Section 7, Appendix-2(Price Adjustment) ofSection 9(Contract Forms) and on the actual quantity of plant & services completed by
the Contractor during the contract execution stage as per unit price of the contract.Bidders are required to provide the labor & material indices and source of indices in theirbids using the form in Schedule K, volume 3 of 3 of the bidding document. If any bidderdoes not furnished the Schedule K, that bidder will not get any price escalation as perAppendix-2 of Section 9.
3. Section no. 3: Evaluation and Qualification Criteria, Page no.3-2 & 3-3, Sub-clause 1.2.6:
i) The following para is added after the para (f)
(g) In comparision of bids, only the CIF price component of each bid for the plant & equipment[which areoffered from domestically by other bidder(s) as mentioned (a) above] offered from outside thePurchasers country shall be increased by fifteen percent(15%) for evaluation purpose.
ii) The text the bidders are required to submit the documents establishing in last para is replaced by the textthe bidders are required to submit the documents in their Price Proposal establishing
iii) The text with the provisions specified in the latest Public Procurement Regulations of the Govt. ofBangladesh and in the 2nd & 3rd line of 1st para is deleted.
4. Section no. 3: Evaluation and Qualification Criteria, Page no.3- 3, Sub-clause 1.2.8:
i) The following sub-clause 1.2.7 is added after sub-clause 1.2.61.2.7 For calculating the evaluated price, the Tender Evaluation Committee(TEC) shall-
(a) exclude applicable custom duties, taxes and VAT in the case of CIF Prices for imported Goods andexclude only VAT for Goods manufactured locally.
8/2/2019 Clarification of Kulaora Sherpur
13/36
The sub-clause GC 11.2 is replaced by the following :Replacing Clause GC 11.2
The prices quoted by the Bidder shall be adjusted in accordance with the provisions of Appendix-
2(Price Adjustment) of Section 9:Contract Forms and on the actual quantity of plant & servicescompleted by the Contractor during the contract execution stage as per unit price of the contract.
8. Section no. 8: Special Conditions of Contract, Page no.8-18, Sub-clause GC 45.5:
The text of Bangladesh is added at the end of the sentence.
9. Section 9: Contract Forms, Page no. 9-9, Appendix 2:
a) In formula the abbreviationP0=Ex-works/CIF price of the Transformer, less advanceis replaced byP0=Ex-works/FOB price of the Transformer, less advance
b) the condition (c) is replaced by The above payment implication due to the Price Escalation will be settled atthe end of Contract. Such payment implication shall not exceed a total ceiling of 15 percent of contract priceof Power Transformer item only.
Volume 2 of 3
10.Section no.5: Substation Automation System(Protection, Control and Metering), Clause 5.12.1, Pageno.5/24, 2nd para:
The text For standardization of operation performance, facilities and spare requirements, the main protectiverelays and control systems to be supplied under this project shall comprise Alstom (France/UK), ABB(Switzerland/Sweden) and Siemens (Germany) make manufactureis replaced by For standardization of operation performance, facilities and spare requirements, the mainprotective relays and control systems including complete panel to be supplied under this project shall comprise
ABB (Switzerland/Sweden), former Areva (France/UK) and Siemens (Germany) make manufacture.
11.Section no.7: Earthing system, Clause 7.8.2, Page no.7/8, 2nd para, 2nd line and 3rd para 2nd line:
The word bare is replaced by insulated and flexible.
12.Section no.7: Earthing system, Clause 7.8.3, Page no.7/9, 4th para, 2nd line and 3rd para 2nd line:
The word 150 mm2 is replaced by 120 mm2
13.Section no.7: Earthing system, Clause 7.8.4, Page no.7/9, 1st para, last line:
The last line The bare copper conductor size shall have a minimum cross section area of 150 mm2 is replacedby The insulated and flexible copper conductor size shall have a minimum cross section area of 120 mm2 .
14 Drawings:
8/2/2019 Clarification of Kulaora Sherpur
14/36
In the last line the text ICC Publication No. 458 is replaced by ICC Publication No. 758.
16.Schedule A: Requirements, Item no. 3D.1 & 3D.2, Page no. SA-16:
The words Substation Automation System is added after the words Control, Protection.
17.Schedule A: Requirements, Page no. SA-15:(i) A new item 3A3.1 is added after the item no. 3A3 as follows:
3A3.1 Two (2) sets of 145kV, 2000A, 31.5kA/1sec, 50Hz, 650kVp BIL, double side break, post type, motoroperated disconnectors without earthing switch for bustie bay.
(ii) Item 3A4.2 is revised as follows:
3A4.2 Fifteen (15) nos. of single-phase, 4-core, multi ratio, 145kV, 31.5kA/1sec, 50Hz,650kVp BIL, posttype current transformer (3core:1250-800/1A; 1core:2000/1A). Dismantle of existing CT withstructures, supply of new CT with new structures and modification of existing CT foundations are tobe carried out.
Page SA-15 is replaced by the revised Page SA-15 (Rev.1) and attached herewith.
18.Schedule A: Requirements, Page no. SA-16:
A new item 3D1.1 is added after the item no. 3D1 as follows:
3D1.1 Control, Protection, Substation Automation System and Metering for existing two(2) sets of overheadline circuits and three(3) sets of 132/33kV Power Transformer(including33kVincomer)circuits. Existingcontrol/protection/metering panels shall be replaced by the new panels. The existing panels are to bedismantled and handed over to Grid Maintenance Division(GMD) store.
Page SA-16 is replaced by the revised Page SA-16 (Rev.1) and attached herewith.
19.Schedule A: Requirements, Item no. 3G2, Page no. SA-17:
Item 3G2 is replaced as follows:
3G2 One (1) lot of all necessary switchgears and interconnection cables required for extension of existing48V DC system to provide service of the plant and equipment to be supplied under this contract andOne (1) set of UPS for SAS panels.
20.Schedule A: Requirements, Item no. 3I1 & 3I2, Page no. SA-17:
Item 3I1 & 3I2 are replaced as follows:
3I1 One (1) lot of complete design, supply and construction of all civil items required for the outdoor workssuitable for switchyard gantry & equipment foundations, internal roads, cable trenches, surfacing,drainage, fences, etc. to accommodate extension of two 132kV line bays and bustie bay at new
8/2/2019 Clarification of Kulaora Sherpur
15/36
3L1 One (1) lot of complete design, supply, delivery, installation, testing & commissioning of hardware andsoftware to provide the telecontrol & telemetering facilities required at the existing National LoadDespatch Center (NLDC) at Rampura for integration of new two 132kV overhead line bays to Sherpursubstation, existing two 132kV line bays to Mymensing, existing three 132/33kV Power Transformer
(including 33kV incomer) bays and 132kV bustie bay. All required electrical signals shall be transmittedto the NLDC through the Industrial Gateway of the substation automation system. All HV breakers,motorized disconnectors, tap changer, etc. shall be controlled form NLDC through the Gateway of thesubstation automation system using IEC 60870-5-101/104 protocol. All necessary modification works inthe software of master station of NLDC are to be carried out.
Page SA-18 is replaced by the revised Page SA-18 (Rev.1) and attached herewith.
22.Schedule A: Requirements, Appendix-A1, Page no. SA-23 to SA-25:
Pages SA-23, SA-24 and SA-25 are replaced by the revised Pages SA-23 (Rev.1), SA-24(Rev.1), SA-25(Rev.1) and attached herewith.
23.Schedule B: Price Schedule, Page no. SB-11 to SB-13
In the Title Schedule B4 is replaced by Schedule B2.
24.Schedule B: Price Schedule, Page no. SB-14 to SB-21
In the Title Schedule B3 is replaced by Schedule B2.
25.Schedule B: Price Schedule, Page no. SB-22 to SB-24
In the Title Schedule B5 is replaced by Schedule B2.
26.Schedule B2: Price for Itemized Works, Page no. SB-9 & SB-20
A new item 3D1.1 is added after the item no. 3D1 and item 3D2 is corrected. Page SB-9 & SB-20 are replacedby the revised pages SB-9(Rev.1) & SB-20(Rev.1) and attached herewith.
27.Schedule B2: Price for Itemized Works suppl ied within Employers Country, Page SB-14 to SB-24
The EXW prices are to be quoted excluding VAT and VAT on EXW shall be quoted in separate column inBangladesh Taka. VAT on EXW shall be included in the Contract Price. The Contractor shall pay the VAT onEXW and PGCB will reimburse it at actual basis but not more than the quoted amount upon submission ofrelevant document.
The format of the Price schedule for Itemized Works supplied within Employers Country, Page no. SB-14 toSB-24 are replaced by the revised pages SB-14(Rev.1) to SB-24(Rev.1) and attached herewith.
28.Schedule B7: Prices for Variations, Page no. SB-33 to SB-34
The pages SB-33 & SB-34 are deleted.
8/2/2019 Clarification of Kulaora Sherpur
16/36
8/2/2019 Clarification of Kulaora Sherpur
17/36
8/2/2019 Clarification of Kulaora Sherpur
18/36
Schedule_A: Requirements
2K2 Underground optical fibre cables (24cores for 132kV switchyard) from terminalbox gantry structure at each 132kV double circuit transmission line termination
point to MDF (Main distribution Frame) to be installed in control room. TheContract includes supply and installation of MDF and pigtail cables withadequate length.
2L SCADA system for Telecontrol and Telemetering
2L1 One (1) lot of complete design, supply, delivery, installation, testing &commissioning of hardware and software to provide the telecontrol &telemetering facilities required at the existing National Load Despatch Center
(NLDC) at Rampura for integration of complete new 132/33kV substation. Allrequired electrical signals shall be transmitted to the NLDC through theIndustrial Gateway of the substation automation system. All HV breakers,motorized disconnectors, tap changer, etc. shall be controlled form NLDCthrough the Gateway of the substation automation system using IEC 60870-5-101/104 protocol. All necessary modification works in the software of masterstation of NLDC are to be carried out.
3) Extension of Existing 132kV AIS Substation at Jamalpur
The equipment to be designed, supplied, installed, tested & commissioned asstipulated in bid specification and shown in bid drawings (volume 2 of 3):
Item Description
3A 145kV Air Insulated Switchgear (AIS)
The 145kV AIS shall comply with the particular requirements as detailed in theSchedule of Technical Requirements included as Appendix A1 to this section
and shall comprise the following:-
3A1.1 Two (2) sets of 145kV, 1250A, 31.5kA/1sec, 50Hz, 650kVp BIL, live tank type, singlepole operated, SF6 gas circuit breakers with spring-stored energy operatingmechanism or spring-hydraulic combination mechanism (for line bay).
3A1.2 One (1) sets of 145kV, 2000A, 31.5kA/1sec, 50Hz, 650kVp BIL, live tank type, gangoperated, SF6 gas circuit breakers with spring-stored energy operating mechanism orspring-hydraulic combination mechanism (for bustie bay).
3A2 Two (2) sets of 145kV, 1250A, 31.5kA/1sec, 50Hz, 650kVp BIL, double side
break, post type, motor operated disconnectors with earthing switch.
3A3 Four (4) sets of 145kV, 1250A, 31.5kA/1sec, 50Hz, 650kVp BIL, double sidebreak, post type, motor operated disconnectors without earthing switch
3A3.1 Two (2) sets of 145kV, 2000A, 31.5kA/1sec, 50Hz, 650kVp BIL, double sidebreak post type motor operated disconnectors without earthing switch for
8/2/2019 Clarification of Kulaora Sherpur
19/36
Schedule_A: Requirements
3A5 Six (6) nos. of single-phase, 3-core, 145kV, 31.5kA/1sec, 50Hz, 650kVp BIL, capacitortype voltage transformers.
3A6 Six (6) nos. of 120kV rated voltage, 102kV(rms) continuous operating voltage at 500C,10kA nominal discharge current, 50Hz, Heavy duty station class, gapless metal oxidetype, single phase surge arresters.
3A7 One (1) lot of flexible bus conductors, insulators, fittings including all necessary clampsand connectors required for completing 145kV busbar and switchgear connection asspecified in the technical specifications and bid drawings.
3A8 One (1) lot of steel structures for gantry and equipment supports required for completing145kV busbar and switchgear as specified in the technical specifications and biddrawings.
3A9 One (1) lot of 145kV post type support insulators required for completing 145kV busbarand switchgear as specified in the technical specifications and bid drawings.
3D Control, Protection, Substation Automation & Metering
132 kV CircuitsThe equipment to be designed, supplied, installed and commissioned is shown in biddrawings are comprising of :-
3D1 Control, Protection, Substation Automation System and Metering for two(2) sets ofoverhead line circuits to Sherpur (Sherpur-1 & 2).
3D1.1 Control, Protection, Substation Automation System and Metering for existing two(2) setsof overhead line circuits and three(3) sets of 132/33kV Power Transformer (including33kV incomer) circuits. Existing control/protection/metering panels shall be replaced by thenew panels. The existing panels are to be dismantled and handed over to Grid Maintena-nce Division(GMD) store.
3D2 Control, Protection, Substation Automation System for one(1) set of Bustie circuits.
3D3 Busbar protection and breaker failure protecting for complete 132kV system in one (1)lot.3D4 Tariff metering panel to accommodate programmable & recordable digital 3-phase, 4-wire
import and export MWh and MVArh meters (accuracy class 0.2) for each 132 kV line andtransformer feeder. For each feeder minimum two meters (main & check). The scope ofworks also includes supply of software(s) of the above energy meters for future re-
fi ti
8/2/2019 Clarification of Kulaora Sherpur
20/36
Schedule_A: Requirements
3G DC Distribution
3G1 One (1) lot of all necessary switchgears and interconnection cables requiredfor extension of existing 110V DC system to provide service of the plant andequipment to be supplied under this contract.
3G2 One (1) lot of all necessary switchgears and interconnection cables requiredfor extension of existing 48V DC system to provide service of the plant andequipment to be supplied under this contract and One (1) set of UPS for SAS
panels.
3H LVAC Distribution
3H1 One (1) lot of all necessary switchgears and interconnection cables requiredfor extension of existing LVAC switchboard for substation services to besupplied, installed and commissioned, to provide the 415/240V supplies to allequipment being supplied under this turnkey Bid.
3I Civil Works, Building and Foundation
3I1 One (1) lot of complete design, supply and construction of all civil itemsrequired for the outdoor works suitable for switchyard gantry & equipmentfoundations, internal roads, cable trenches, surfacing, drainage, fences, etc. toaccommodate extension of two 132kV line bays and bustie bay at newlocation.
3I2 One (1) lot of complete design, supply and construction of all civil itemsrequired for modification of existing control building suitable to accommodatenecessary panels for extension of two 132kV line bays and all existing 132kVbays.
3J Lighting, Small Power, Air Conditioning and Ventilation
3J1 One (1) lot of complete set of design, supply, installation and commissioning ofequipment to provide lighting (flood light; sodium/mercury) for security,roadway, switchyard and emergency DC lighting at strategic locations forequipment operation and inspection required for all equipment being suppliedunder this turnkey Bid..
8/2/2019 Clarification of Kulaora Sherpur
21/36
Schedule_A: Requirements
MSE5001 type.
3K2 Underground optical fibre cables (24cores for 132kV switchyard) from terminalbox gantry structure at each 132kV double circuit transmission line terminationpoint to MDF (Main distribution Frame) installed in control room. The Contractincludes supply and installation pigtail cables with adequate length.
3L SCADA system for Telecontrol and Telemetering
3L1 One (1) lot of complete design, supply, delivery, installation, testing &
commissioning of hardware and software to provide the telecontrol &telemetering facilities required at the existing National Load Despatch Center(NLDC) at Rampura for integration of new two 132kV overhead line bays toSherpur substation, existing two 132kV line bays to Mymensing, existing three132/33kV Power Transformer (including 33kV incomer) bays and 132kV bustiebay. All HV breakers, motorized disconnectors, tap changer, etc. shall becontrolled form NLDC through the Gateway of the substation automationsystem using IEC 60870-5-101/104 protocol. All necessary modification works
in the software of master station of NLDC are to be carried out.
3l2 One (1) lot of complete design, supply, delivery, installation, testing &commissioning of hardware and software to provide the telecontrol &telemetering facilities required at the existing National Load Despatch Center(NLDC) at Rampura for integration of two new 132kV line bays. All necessarymodification works in the software of master station of NLDC are to be carriedout.
4) Mandatory Spares, Erection & Test Equipment
Supply of complete spares and spare parts of transformer, switchgear, controlequipment, protection relays, meters, erection & test equipment as per quantitymentioned in Schedule B. Test equipment are to be supplied from Europe,USA or Japan origin. Printed catalogue, operation and service manual are tobe provided. The materials shall have to be handed over to the designated
store as per instruction of the Engineer.
8/2/2019 Clarification of Kulaora Sherpur
22/36
Schedule_A: Requirements
MHz to 2 MHz (at 92 kVrms) (at 92 kVrms)
6 Partial discharge level 10 pC 10 pC
7 Type of insulation Class A Class A
6.2.1 145kV Class Current Transformers (for transformer bay)
1 No. of Cores 4
2 Ratio 600-300/1/1/12000/1
3 Class of accuracy - Busbar Protection : 5P20
- Protection : 5P20- Metering : Class 0.2
4 Burden (VA) 30
5 Min. knee point voltage at lowest ratio (Volts) 600 and over
6 Max. magnetizing current guaranteed atknee point voltage & the lowest ratio (mA)
M.R
7 Max. resistance of secondary winding at75
0C and at lowest ratio (ohms)
M.R
6.2.2 36kV Class Current Transformers (for transformer bay)
1 No. of Cores 3
2 Ratio 1200-800/1/1/1
3 Class of accuracy - Protection : 5P20
- Metering : Class 0.2
4 Burden (VA) 30
5 Min. knee point voltage at lowest ratio (Volts) 600 and over
6 Max. magnetizing current guaranteed atknee point voltage & the lowest ratio (mA)
M.R
7 Max. resistance of secondary winding at
750
C and at lowest ratio (ohms)
M.R
6.3 145kV Class Current Transformers (for line bay)
1 No. of Cores 4
2 Ratio 1200-800/1/1/12000/1
8/2/2019 Clarification of Kulaora Sherpur
23/36
Schedule_A: Requirements
1 No. of Cores 5
2 Ratio 1200-800/1/1/1
2000/1
3 Class of accuracy - Busbar Protection : 5P20- Protection : 5P20- Metering : Class 0.2
4 Burden (VA) 30
5 Min. knee point voltage at lowest ratio (Volts) 600 and over
6 Max. magnetizing current guaranteed atknee point voltage & the lowest ratio (mA)
M.R
7 Max. resistance of secondary winding at 750C and at lowest ratio (ohms)
M.R
6.4 145kV Class Current Transformers (for bus coupler bay)
1 Core No. I II
2 Ratio 2000/1 2000/13 Purpose Protection Measuring
4 Class of accuracy 5P20 0.5
5 Burden(VA) 30 30
6 Min. knee point voltage atlowest ratio(Volts)
600 and over 600 and over
7 Max. magnetisingcurrent guaranteed atknee point voltage & thelowest ratio(mA)
M.R M.R
8 Max. resistance ofsecondary winding at75
0C and at lowest ratio
(ohms)
M.R M.R
6.5 145kV Class Voltage Transformer1 Rated voltage levels 145 kV
2 High frequency capacitance forentire carrier frequency range
Within 80% to 150% of ratedcapacitance
8/2/2019 Clarification of Kulaora Sherpur
24/36
Schedule_A: Requirements
8 Stray capacitance and strayconductance of low voltage terminal
over the entire capacitance.
As per IEC-358
9 Core details Core-I : Core-II : Core-III :
10 Purpose Protection Protection Metering
11 Secondary Voltage 110/3 110/3 110/3
12 Burden (VA) 150 150 150
13 Class of accuracy 3P 3P 0.2
14 Rated total thermal burden(VA) 200 200 20015 One minute power frequency
withstand voltage between LVterminal and earth(kV rms)
4(10 if the low voltage terminal isexposed)
16 Withstand voltage for secondarywinding (kV rms)
2
6.6 36kV Class Voltage Transformer
1 Rated voltage levels 36 kV
2 Rated Voltage Factor 1.2 continuous; 1.5 for 30 seconds
3 Phase angle error (minutes) 20
4 Core details Core-I : Core-II :
5 Purpose Protection Metering
6 Secondary Voltage 110/3 110/3
7 Burden (VA) 50 25
8 Class of accuracy 3P 0.2
9 One minute power frequencywithstand voltage between LVterminal and earth(kV rms)
4(10 if the low voltage terminal isexposed)
10 Withstand voltage for secondary
winding (kV rms)
2
7 Surge Arresters
1 Max. highest system voltage 145kV 36kV
2 Type Outdoor type, ZnO, Gapless
8/2/2019 Clarification of Kulaora Sherpur
25/36
Item Description Unit Qty Country Unit Total Insurance Freight Total Erection Design Total F/C Local Local Erection Design Total L/C
of Origin Price Price Price Cost cost Cost transport & Insurance Cost cost Cost
FOB FOB CIF handling cost
1 2 3=1x2 4 5 6=3+4+5 7 8 9=6+7+8 10 11 12 13 14=10+11+12+13
3A145kV Switchgear, equipment connections, steel
structures
3A1.1SF6 Circuit breaker, live tank, single pole operating,
1250A
sets 2
3A1 .2 SF6 Ci rcui t b reaker , l ive t ank, gang operat ing, 2000A sets 1
3A2 Disconnector switch with E/S, 1250A sets 2
3A3 Disconnector switch without E/S, 1250A sets 4
3A3.1 Disconnector switch without E/S, 2000A sets 2
3A4.1 Single phase current transformer (4 cores) nos. 6
3A4.2 Single phase current transformer (4 cores) nos. 15
3A4.3 Single phase current transformer (2 cores) nos. 6
3A5 Single phase capacitive voltage transformer nos. 6
3A6 Single phase surge arresters nos. 6
3A7Conductor for Busbar & equipment connection with
insulator disc & fittingsLot 1
3A8Structures (Equipment support, Gantry tower and
Beams)Lot 1
3A9 Post type insulators Lot 1
3DControl, Protection, Substation Automation &
Metering
132kV Circuits
3D1
Control, Protection, Metering & Substation Automation
System includingevent recording function for overhead line
circuits
Sets 2
3D1.1Control, Protection, Metering & Substation Automation
System including event recording function for replacement
of existing two overhead line circuits and three Transformer
circuits(including 33kV incomer)
Sets 5
3D2 Control, Protection, Metering & Substation Automation
System including event recording function for bustie bay
Lot 1
3D3 Busbar & Breaker fail protection for complete132kV
systemLot 1
3D4
Tariff metering panel to accommodate programmable &
recordable digital 3-phase, 4-wire import and export MWh
and MVArh meters (accuracy class 0.2) for each 132 kV
line and transformer feeder. For each feeder minimum two
meters (main & check).
Lot 1
Sub-Total Price carried forward
Sub Total Price in words............................................................................................................................................................................
Schedule B: Bid Price SB-9 (Rev.1)
DESIGN, SUPPLY, ERECTION, TESTING & COMMISSIONING OF THREE 132/33 KV AIR INSULATED SWITCHGEAR (AIS) SUBSTATIONS AT KULAORA & SHERPUR AND EXTENSION OF
EXISTING 132/33 KV SUBSTATIONS AT JAMALPUR ON TURNKEY BASIS
SCHEDULE B2: Price for Itemised Works, Goods or Services Supplied from outside the Employer's Country
(in Bangladesh Taka)Foreign Currency (F/C) Price (in... )Section-3: Extension of existing 132 kV Substation at Jamalpur
Local Currency (L/C) Price
8/2/2019 Clarification of Kulaora Sherpur
26/36
Bangladesh Taka :
Unit Price Total Price VAT Unit Price Total Price VAT Transport Erection Insurance Design Total Price
EXW EXW on EXW EXW EXW on EXW & Handling
excl. VAT exclude VAT in BDT exclude VAT exclude VAT
1 2 3=2x1 4 5 6=1x5 7 8 9 10 11 12=6+7+8+9+10+11
1A145kV Switchgear, equipment connections,
steel structures
1A1SF6 Circuit breaker, live tank, gang operating,
2000Aset 1
1A2.1
SF6 Circuit breaker, live tank, gang operating,
1250A sets 2
1A2.2SF6 Circuit breaker, live tank, single pole
operating, 1250Asets 2
1A3 Disconnector switch without E/S, 2000A sets 2
1A4 Disconnector switch with E/S, 1250A sets 4
1A5 Disconnector switch without E/S, 1250A sets 8
1A6 Single phase current transformer (2 cores) sets 6
1A7 Single phase current transformer (4 cores) nos. 12
1A8.1 Single phase capacitive voltage transformer nos. 6
1A8.2 Single phase inductive voltage transformer nos. 12
1A9 Single phase surge arresters nos. 12
1A10 Conductor for Busbar & equipment connectionwith insulator disc & fittings
Lot 1
1A11Structures (Equipment support, Gantry tower and
Beams)Lot 1
1A12 Post type insulators nos. 6
1B33 kV Switchgear, equipment connections,
steel structures
1B1 Vacuum circuit breaker, 2000A sets 2
1B2 Disconnector, single vertical break sets 3
1B3 Single phase current transformer nos. 6
1B4 Single phase voltage transformer nos. 6
1B5 Single phase surge arresters nos. 12
1B6 Conductor for Busbar & equipment connectionwith insulator disc & fittings
Lot 1
1B7Structures (Equipment support, Gantry tower and
Beams)Lot 1
1C Power Transformers & Auxiliary Transformers
1C1 132/33 kV, 25/41 MVA power transformer sets 2
1C2
33/0.4 kV auxiliary transformer with netutral
grounding resisters, support structure and
connections
sets 2
Sub Total Price in words..........................................................................................................................................................................Schedule B: Bid Price SB-14(Rev.1)
SCHEDULE B2: Price for Itemised Works, Goods or Services Supplied from within the Employer's Country
Section-1: New 132/33 kV Substation at KULAORALocal Currency (L/C) Cost
UnitQty
DESIGN, SUPPLY, ERECTION, TESTING & COMMISSIONING OF THREE 132/33 KV AIR INSULATED SWITCHGEAR (AIS) SUBSTATIONS AT KULAORA & SHERPUR AND
EXTENSION OF EXISTING 132/33 KV SUBSTATIONS AT JAMALPUR ON TURNKEY BASIS
Sub-Total Price carried forward
Foreign Curreny in .
Item Description
Country of
origin
8/2/2019 Clarification of Kulaora Sherpur
27/36
SCHEDULE B2: Price for Itemised Works, Goods or Services Supplied from within the Employer's Country
DESIGN, SUPPLY, ERECTION, TESTING & COMMISSIONING OF THREE 132/33 KV AIR INSULATED SWITCHGEAR (AIS) SUBSTATIONS AT KULAORA & SHERPUR AND
EXTENSION OF EXISTING 132/33 KV SUBSTATIONS AT JAMALPUR ON TURNKEY BASIS
Bangladesh Taka :
Unit Price Total Price VAT Unit Price Total Price VAT Transport Erection Insurance Design Total Price
EXW EXW on EXW EXW EXW on EXW & Handling
excl. VAT exclude VAT in BDT exclude VAT exclude VAT
1 2 3=2x1 4 5 6=1x5 7 8 9 10 11 12=6+7+8+9+10+11
Sub-Total brought forward
1DControl, Protection, Substation Automation &
Metering
132kV Circuits
1D1
Control, Protection, Metering & Substation Automation
System including event recording function for overhead
line circuits
Sets 4
1D2
Control, Protection & Substation Automation System
including event recording function for 132/33 kV power
transformer circuits including transformer tap changer
control.
Sets 2
1D3 Control, Protection & Substation Automation System
including event recording function for bus coupler circuit.
Lot 1
1D4
Tariff metering panel to accommodate programmable &
recordable digital 3-phase, 4-wire import and export
MWh and MVArh meters (accuracy class 0.2) for each
132 kV line and transformer feeder. For each feeder
minimum two meters (main & check).
Lot 1
33kV Circuits
1D5Control & Protection for power transformer circuits
(Power transformer-I & II)Sets 2
1D6Tariff metering panel to accommodate programmable &
recordable digital 3-phase, 4-wire import and export
MWh and MVArh meters (accuracy class 0.2) for power
transformer circuits (Power transformer-I & II). For each
feeder minimum two meters (main & check)
Lot 1
1E Multicore Cables
1E1Multicore cables for control, protection, metering &
power circuits
Lot 1
1F Earthing and Lightning Protection
1F1 Earthing and Lightning Protection Lot 1
1F2 Portable(maintenance) earthing equipment device Sets 2
1G Batteries, Chargers and DC Distribution
(a) 110V alkaline Batteries Sets 2
(b) 110V Battery Cahrger Sets 2
(c) Distribution board Lot 1
Sub-Total Price carried forward
Sub Total Price in words..........................................................................................................................................................................SB-15(Rev.1)
Schedule B: Bid Price
1G2
Section-1: New 132/33 kV Substation at KULAORALocal Currency (L/C) Cost
Foreign Curreny in .
Item Description UnitQty
Country of
origin
8/2/2019 Clarification of Kulaora Sherpur
28/36
SCHEDULE B2: Price for Itemised Works, Goods or Services Supplied from within the Employer's Country
DESIGN, SUPPLY, ERECTION, TESTING & COMMISSIONING OF THREE 132/33 KV AIR INSULATED SWITCHGEAR (AIS) SUBSTATIONS AT KULAORA & SHERPUR AND
EXTENSION OF EXISTING 132/33 KV SUBSTATIONS AT JAMALPUR ON TURNKEY BASIS
Bangladesh Taka :
Unit Price Total Price VAT Unit Price Total Price VAT Transport Erection Insurance Design Total Price
EXW EXW on EXW EXW EXW on EXW & Handling
excl. VAT exclude VAT in BDT exclude VAT exclude VAT
1 2 3=2x1 4 5 6=1x5 7 8 9 10 11 12=6+7+8+9+10+11
Sub-Total brought forward
(a) 48V alkaline Batteries Sets 2
(b) 110V Battery Charger Sets 2
(c) Distribution board Lot 1
(d) UPS for 48V DC System Set 1
1H LVAC Distribution
1H1 132 kV transformer circuit Lot 1
1H2 Tariff metering panel Lot 1
1I Civil Works, Buildings and Foundation
1I1 Complete civil items for outdoor works Lot 1
1I2Complete civil items and facilities for two storied
Control buildingLot 1
1JLighting, Small Power, Air Conditioning and
Ventilation
1J1Lighting, small power, air conditioning, ventilation
and emergency DC lighting for control buildingLot 1
1J2Linghting for outside building for security,
roadway, switchyard and emergency DC lightingLot 1
1K Fibre Optic Multiplexer Equipment
1K1 Fibre Optic Multiplexer Equipment Lot 1
1K2 Optical Fiber Cable, juctionBox, MDF, pigtail etc. Lot 1
1JSCADA System for Telecontrol and
Telemetering
1J1SCADA system for complete susbtatation with
integration to NLDCLot 1
Total Price in words............................................................................................................................................................................
SB-16(Rev.1)
Schedule B: Bid Price
Total Price carried to Summary of Price Schedule
Foreign Curreny in .Local Currency (L/C) Cost
1G2
Section-1: New 132/33 kV Substation at KULAORA
Item Description UnitQty
Country of
origin
8/2/2019 Clarification of Kulaora Sherpur
29/36
Bangladesh Taka :
Unit Price Total Price VAT Unit Price Total Price VAT Transport Erection Insurance Design Total Price
EXW EXW on EXW EXW EXW on EXW & Handling
excl. VAT exclude VAT in BDT exclude VAT exclude VAT
1 2 3=2x1 4 5 6=1x5 7 8 9 10 11 12=6+7+8+9+10+11
2A145kV Switchgear, equipment connections, steel
structures
2A1SF6 Circuit breaker, live tank, gang operating,
2000Aset 1
2A2.1SF6 Circuit breaker, live tank, gang operating,
1250Asets 2
2A2.2SF6 Circuit breaker, live tank, single pole operating,
1250Asets 2
2A3 Disconnector switch without E/S, 2000A sets 2
2A4 Disconnector switch with E/S, 1250A sets 4
2A5 Disconnector switch without E/S, 1250A sets 8
2A6 Single phase current transformer (2 cores) sets 6
2A7 Single phase current transformer (4 cores) nos. 12
2A8.1 Single phase capacitive voltage transformer nos. 6
2A8.2 Single phase inductive voltage transformer nos. 12
2A9 Single phase surge arresters nos. 12
2A10 Conductor for Busbar & equipment connection withinsulator disc & fittings
Lot 1
2A11Structures (Equipment support, Gantry tower and
Beams)Lot 1
2A12 Post type insulators nos. 6
2B33 kV Switchgear, equipment connections, steel
structures
2B1 Vacuum circuit breaker, 2000A sets 2
2B2 Disconnector, single vertical break sets 3
2B3 Single phase current transformer nos. 6
2B4 Single phase voltage transformer nos. 6
2B5 Single phase surge arresters nos. 12
2B6
Conductor for Busbar & equipment connection with
insulator disc & fittings Lot 1
2B7Structures (Equipment support, Gantry tower and
Beams)Lot 1
2C Power Transformers & Auxiliary Transformers
2C1 132/33 kV, 35/50 MVA power transformer sets 2
2C2
33/0.4 kV auxiliary transformer with netutral
grounding resisters, support structure and
connections
sets 2
Sub Total Price in words............................................................................................................................................................................
Schedule B: Bid Price SB-17(Rev.1)
Sub-Total Price carried forward
Item Description UnitQty
DESIGN, SUPPLY, ERECTION, TESTING & COMMISSIONING OF THREE 132/33 KV AIR INSULATED SWITCHGEAR (AIS) SUBSTATIONS AT KULAORA & SHERPUR AND
EXTENSION OF EXISTING 132/33 KV SUBSTATIONS AT JAMALPUR ON TURNKEY BASIS
SCHEDULE B2: Price for Itemised Works, Goods or Services Supplied from within the Employer's Country
Section-2: New 132/33 kV Substation at Shepur Foreign Curreny in .Local Currency (L/C) Cost
Country of
origin
8/2/2019 Clarification of Kulaora Sherpur
30/36
DESIGN, SUPPLY, ERECTION, TESTING & COMMISSIONING OF THREE 132/33 KV AIR INSULATED SWITCHGEAR (AIS) SUBSTATIONS AT KULAORA & SHERPUR AND
EXTENSION OF EXISTING 132/33 KV SUBSTATIONS AT JAMALPUR ON TURNKEY BASIS
SCHEDULE B2: Price for Itemised Works, Goods or Services Supplied from within the Employer's Country
Bangladesh Taka :
Unit Price Total Price VAT Unit Price Total Price VAT Transport Erection Insurance Design Total Price
EXW EXW on EXW EXW EXW on EXW & Handling
excl. VAT exclude VAT in BDT exclude VAT exclude VAT
1 2 3=2x1 4 5 6=1x5 7 8 9 10 11 12=6+7+8+9+10+11
Sub-Total brought forward
2DControl, Protection, Substation Automation &
Metering
132kV Circuits
2D1
Control, Protection, Metering & Substation Automation
System including event recording function for overhead
line circuits
Sets 4
2D2
Control, Protection & Substation Automation System
including event recording function for 132/33 kV power
transformer circuits including transformer tap changer
control.
Sets 2
2D3 Control, Protection & Substation Automation System
including event recording function for bus coupler circuit.
Lot 1
2D4
Tariff metering panel to accommodate programmable &
recordable digital 3-phase, 4-wire import and export MWh
and MVArh meters (accuracy class 0.2) for each 132 kV
line and transformer feeder. For each feeder minimum two
meters (main & check).
Lot 1
33kV Circuits
2D5Control & Protection for power transformer circuits
(Power transformer-I & II)Sets 2
2D6Tariff metering panel to accommodate programmable &
recordable digital 3-phase, 4-wire import and export MWh
and MVArh meters (accuracy class 0.2) for power
transformer circuits (Power transformer-I & II). For each
feeder minimum two meters (main & check)
Lot 1
2E Multicore Cables
2.00E+0
1
Multicore cables for control, protection, metering &
power circuits Lot 1
2F Earthing and Lightning Protection
2F1 Earthing and Lightning Protection Lot 1
2F2 Portable(maintenance) earthing equipment device Sets 2
2G Batteries, Chargers and DC Distribution
(a) 110V alkaline Batteries Sets 2
(b) 110V Battery Cahrger Sets 2
(c) Distribution board Lot 1
Sub-Total Price carried forward
Sub Total Price in words............................................................................................................................................................................
SB-18(Rev.1)
Schedule B: Bid Price
Section-2: New 132/33 kV Substation at ShepurLocal Currency (L/C) Cost
Foreign Curreny in .
2G2
Item Description UnitQty
Country of
origin
8/2/2019 Clarification of Kulaora Sherpur
31/36
DESIGN, SUPPLY, ERECTION, TESTING & COMMISSIONING OF THREE 132/33 KV AIR INSULATED SWITCHGEAR (AIS) SUBSTATIONS AT KULAORA & SHERPUR AND
EXTENSION OF EXISTING 132/33 KV SUBSTATIONS AT JAMALPUR ON TURNKEY BASIS
SCHEDULE B2: Price for Itemised Works, Goods or Services Supplied from within the Employer's Country
Bangladesh Taka :
Unit Price Total Price VAT Unit Price Total Price VAT Transport Erection Insurance Design Total Price
EXW EXW on EXW EXW EXW on EXW & Handling
excl. VAT exclude VAT in BDT exclude VAT exclude VAT
1 2 3=2x1 4 5 6=1x5 7 8 9 10 11 12=6+7+8+9+10+11
Sub-Total brought forward
(a) 48V alkaline Batteries Sets 2
(b) 110V Battery Charger Sets 2
(c) Distribution board Lot 1
(d) UPS for 48V DC System Set 12H LVAC Dist ribution
2H1 132 kV transformer circuit Lot 1
2H2 Tariff metering panel Lot 1
2I Civil Works, Buildings and Foundation
2I1 Complete civil items for outdoor works Lot 1
2I2Complete civil items and facilities for two storied
Control buildingLot 1
2JLighting, Small Power, Air Conditioning and
Ventilation
2J1Lighting, small power, air conditioning, ventilation
and emergency DC lighting for control buildingLot 1
2J2Linghting for outside building for security, roadway,
switchyard and emergency DC lightingLot 1
2K Fibre Optic Multiplexer Equipment
2K1 Fibre Optic Multiplexer Equipment Lot 1
2K2 Optical Fiber Cable, juctionBox, MDF, pigtail etc. Lot 1
2J SCADA System for Telecontrol and Telemetering
2J1SCADA system for complete susbtatation with
integration to NLDCLot 1
Total Price in words............................................................................................................................................................................
SB-19(Rev.1)
Schedule B: Bid Price
Total Price carried to Summary of Price Schedule
Foreign Curreny in .Local Currency (L/C) Cost
2G2
Section-2: New 132/33 kV Substation at Shepur
Item Description UnitQty
Country of
origin
8/2/2019 Clarification of Kulaora Sherpur
32/36
Bangladesh Taka :
Item Description Unit Qty Country Unit Price Total Price VAT Unit Price Total Price VAT Transport Erection Insurance Design Total Price
of origin EXW EXW on EXW EXW EXW on EXW & Handling
excl. VAT xclude VA in BDT exclude VAT exclude VAT
1 2 3=2x1 4 5 6=1x5 7 8 9 10 11 12=6+7+8+9+10+11
3A145kV Switchgear, equipment connections,
steel structures
3A1.1SF6 Circuit breaker, live tank, single pole
operating, 1250A
sets 2
3A1.2SF6 Circuit breaker, live tank, gang operating,
2000Asets 1
3A2 Disconnector switch with E/S, 1250A sets 2
3A3 Disconnector switch without E/S, 1250A sets 4
3A3.1 Disconnector switch without E/S, 2000A sets 2
3A4.1 Single phase current transformer (4 cores) nos. 6
3A4.2 Single phase current transformer (4 cores) nos. 15
3A4.3 Single phase current transformer (2 cores) nos. 6
3A5 Single phase capacitive voltage transformer nos. 6
3A6 Single phase surge arresters nos. 6
3A7
Conductor for Busbar & equipment connection
with insulator disc & fittings Lot 1
3A8Structures (Equipment support, Gantry tower and
Beams)Lot 1
3A9 Post type insulators Lot 1
3DControl, Protection, Substation Automation &
Metering
132kV Circuits
3D1
Control, Protection, Metering & Substation Automation
System including event recording function for overhead
line circuits
Sets 2
3D1.1
Control, Protection, Metering & Substation Automation
System including event recording function forreplacement of existing two overhead line circuits and
three Transformer circuits(including 33kV incomer)
Sets 5
3D2 Control, Protection, Metering & Substation Automation
System including event recording function for bustie bay
Lot 1
3D3Busbar & Breaker fail protection for complete132kV
systemLot 1
3D4recordable digital 3-phase, 4-wire import and export
MWh and MVArh meters (accuracy class 0.2) for eachLot 1
Sub Total Price in words
..........................................................................................................................................................................Schedule B: Bid Price SB-20 (Rev.1)
DESIGN, SUPPLY, ERECTION, TESTING & COMMISSIONING OF THREE 132/33 KV AIR INSULATED SWITCHGEAR (AIS) SUBSTATIONS AT KULAORA & SHERPUR AND
EXTENSION OF EXISTING 132/33 KV SUBSTATIONS AT JAMALPUR ON TURNKEY BASIS
Sub-Total Price carried forward
SCHEDULE B2: Price for Itemised Works, Goods or Services Supplied from within the Employer's Country
Section-3: Extension of existing 132 kV Substation at JamalpurLocal Currency (L/C) Cost
Foreign Curreny in .
8/2/2019 Clarification of Kulaora Sherpur
33/36
DESIGN, SUPPLY, ERECTION, TESTING & COMMISSIONING OF THREE 132/33 KV AIR INSULATED SWITCHGEAR (AIS) SUBSTATIONS AT KULAORA & SHERPUR AND
EXTENSION OF EXISTING 132/33 KV SUBSTATIONS AT JAMALPUR ON TURNKEY BASIS
SCHEDULE B2: Price for Itemised Works, Goods or Services Supplied from within the Employer's Country
Bangladesh Taka :
Item Description Unit Qty Country Unit Price Total Price VAT Unit Price Total Price VAT Transport Erection Insurance Design Total Price
of origin EXW EXW on EXW EXW EXW on EXW & Handling
excl. VAT xclude VA in BDT exclude VAT exclude VAT
1 2 3=2x1 4 5 6=1x5 7 8 9 10 11 12=6+7+8+9+10+11
Sub-Total brought forward
3E Multicore Cables
3E.1Multicore cables for control, protection, metering &
power circuitsLot 1
3F Earthing and Lightning Protection
3F1 Extension of Earthing and Lightning Protection Lot 1
3G Batteries, Chargers and DC Distribution
3G1 Extension of existing 110V DC System Lot 1
3G2 Extension of existing 48V DC System Lot 1
3H LVAC Distribution
3H1 Extension of LVAC Distribution Lot 1
3I Civil Works, Buildings and Foundation
3I1 Complete civil items for outdoor works Lot 1
3I2Complete civil items for modificaion of existing
control roomLot 1
3J Lighting, Small Power, Air Conditioning andVentilation
3J1Linghting for outside building for security,
roadway, switchyard and emergency DC lightingLot 1
3K Fibre Optic Multiplexer Equipment
3K1Extension of exisitng Fibre Optic Multiplexer
EquipmentLot 1
3K2 Optical Fiber Cable, juctionBox, MDF, pigtail etc. Lot 1
3LSCADA System for Telecontrol and
Telemetering
3L1Extension of exisittng RTU to accomodate two
new line bays to SCADA systemLot 1
3L2 Integration two new line bays to NLDC Lot 1
Total Price in words............................................................................................................................................................................
Schedule B: Bid Price SB-21(Rev.1)
Section-3: Extension of existing 132 kV Substation at JamalpurLocal Currency (L/C) Cost
Foreign Curreny in .
Total Price carried to Summary of Price Schedule
8/2/2019 Clarification of Kulaora Sherpur
34/36
Bangladesh Taka :
Item Description Unit Qty Country Unit Price Total Price VAT Unit Price Total Price VAT Transport Erection Insurance Design Total Price
of origin EXW EXW on EXW EXW EXW on EXW & Handling
excl. VAT xclude VA in BDT exclude VAT exclude VAT
1 2 3=2x1 4 5 6=1x5 7 8 9 10 11 12=6+7+8+9+10+11
4A 145kV Switchgear
4A1Complete 132kV Circuit Breaker (offered type) for
line bayset 1
4A2Complete 132kV Circuit Breaker (offered type) for
transformer bayset 1
4A3Complete 132kV disconnector switch (offered
type) without earth switch of 1250Aset 1
4A4Complete 132kV disconnector switch (offered
type) with earth switch of 1250Aset 1
4A5Complete 132kV disconnector switch (offered
type) with earth switch of 2000Aset 1
4A6
Set (3 phase) interrupting chamber including
insulators, fixed and moving contacts for 132kV
circuit breakers
sets 2
4A7 132kV post insulators suitable for disconnector nos. 6
4A8 Set (3 phase) contacts fo r 132kV d isconnector se ts 3
4A9 132kV surge arrester nos. 6
4A10 132kV post type capacitive voltage transformer nos. 2
4A11 132kV post type current transformer nos. 8
4A12 132kV post insulator nos. 3
4A13 Set (3 phase) gaskets for 132kV circuit breaker sets 2
4A14 Closing coils nos. 4
4A15 Tripping coils nos. 4
4A16 Lot of special grease and lubricant Lot 2
4A17Motor for 132kV circuit breaker operating
mechanismnos. 2
4A18 Motor for disconnector drive nos. 4
4A19 Silica gel (100%) Lot 1
4A20 Transformer oil
20% of
the total
supply
4A21 Coils for Blocking magnet in disconnector drive nos. 4
4B 33kV Switchgear
4B1 33kV disconnector with E/S, 2000A sets 2
4B2 33kV disconnector without E/S, 2000A sets 2
Sub Total Price in words..........................................................................................................................................................................
Schedule B: Bid Price SB-22(Rev.1)
DESIGN, SUPPLY, ERECTION, TESTING & COMMISSIONING OF THREE 132/33 KV AIR INSULATED SWITCHGEAR (AIS) SUBSTATIONS AT KULAORA & SHERPUR AND
EXTENSION OF EXISTING 132/33 KV SUBSTATIONS AT JAMALPUR ON TURNKEY BASIS
SCHEDULE B2: Price for Itemised Works, Goods or Services Supplied from within the Employer's Country
Section-4: Mandatory SparesLocal Currency (L/C) Cost
Foreign Curreny in .
Sub-Total Price carried forward
8/2/2019 Clarification of Kulaora Sherpur
35/36
DESIGN, SUPPLY, ERECTION, TESTING & COMMISSIONING OF THREE 132/33 KV AIR INSULATED SWITCHGEAR (AIS) SUBSTATIONS AT KULAORA & SHERPUR AND
EXTENSION OF EXISTING 132/33 KV SUBSTATIONS AT JAMALPUR ON TURNKEY BASIS
SCHEDULE B2: Price for Itemised Works, Goods or Services Supplied from within the Employer's Country
Bangladesh Taka :
Item Description Unit Qty Country Unit Price Total Price VAT Unit Price Total Price VAT Transport Erection Insurance Design Total Price
of origin EXW EXW on EXW EXW EXW on EXW & Handling
excl. VAT xclude VA in BDT exclude VAT exclude VAT
1 2 3=2x1 4 5 6=1x5 7 8 9 10 11 12=6+7+8+9+10+11
Sub-Total brought forward
4C TRANSFORMERS
4C1 Power transformer 132kV bushings(i) for 50/75 MVA no 1
(ii) for 25/41 MVA no 1
4C2 Power transformer 33kV bushings
(i) for 50/75 MVA no 1
(ii) for 25/41 MVA no 1
Sets of tap changer spares details:
Fixed & moving Contacts
"O-ring gasket
Motor protective switch
Aux. contact K20
Set of motor Contact K1 & K2
4D PROTECTION
4D1
132kV distance relay complete with auto reclose,
synchrocheck relay and over current & earth fault
relay
no. 1
4D2 132kV Transformer Biased (3-phase) relay no. 1
4D3Two pole overcurrent and earth fault relay for
transformerno 1
4D4Busbar protection relay unit complete with trip
relaysno. 1
4D5Breaker failure protection relay unit complete with
timers & trip relaysno. 1
Sub-Total Price carried forward
Sub Total Price in words..........................................................................................................................................................................
Schedule B: Bid Price SB-23(Rev.1)
4C3 Set
Section-4: Mandatory SparesLocal Currency (L/C) Cost
Foreign Curreny in .
1
8/2/2019 Clarification of Kulaora Sherpur
36/36
DESIGN, SUPPLY, ERECTION, TESTING & COMMISSIONING OF THREE 132/33 KV AIR INSULATED SWITCHGEAR (AIS) SUBSTATIONS AT KULAORA & SHERPUR AND
EXTENSION OF EXISTING 132/33 KV SUBSTATIONS AT JAMALPUR ON TURNKEY BASIS
SCHEDULE B2: Price for Itemised Works, Goods or Services Supplied from within the Employer's Country
Bangladesh Taka :
Item Description Unit Qty Country Unit Price Total Price VAT Unit Price Total Price VAT Transport Erection Insurance Design Total Price
of origin EXW EXW on EXW EXW EXW on EXW & Handling
excl. VAT xclude VA in BDT exclude VAT exclude VAT
1 2 3=2x1 4 5 6=1x5 7 8 9 10 11 12=6+7+8+9+10+11
Sub-Total brought forward
4D6 Tripping relay (electrical reset)/trip relay card if in-built no. 1
4D7 Trip circuit supervison relay no. 1
4H8
Programmable energy meter (offered type)
including necessary software for future
reconfiguration
nos. 4
4E POWER & CONTROL CABLES
Spare cable comprising
4E.1 length auxiliary power cable, 19 cores meter 500
4E.2 length control cable, 7 cores meter 500
4E.3 length control cable, 12 cores meter 500
4G DC SWITCHGEARS
4G1 Battery fuses nos. 4
4G2 Set DC board incoming MCCB nos. 44G3 Sets outgoing MCBs nos. 4
4H LVAC SWITCHGEARS
4H1 3-phase set LVAC board incoming MCCb nos. 2
4H2 3-phase sets outgoing MCCBs nos. 4
4H3 1-phase sets outgoing MCBs nos. 4
Total Price in words............................................................................................................................................................................
Note:(page SB-14 to SB-24)The EXW prices are to be quoted excluding VAT and VAT on EXW shall be quoted in separate column in Bangladesh Taka. VAT on EXW shall be included in the Contract Price.
The Contractor shall pay the VAT on EXW and PGCB will reimbursed it at actual basis but not more than the quoted amount upon submission of relevant document.
Schedule B: Bid Price SB-24(Rev.1)
Total Price carried to Summary of Price Schedule
Section-4: Mandatory Spares Foreign Curreny in .Local Currency (L/C) Cost
Recommended